REPAIR-MASTER ® for ...
WHIRLPOOL-KENMORE
GAS & ELECTRIC DRYERS
* DIAGNOSIS CHARTS
* CHECKING PROCEDURE
* SERVICE PROCEDURE
* COMPONENT DATA
* PARTS LISTS
- MASTER Publications No. 8051
- Softcover book
- © Copyright 1978
Contents include:
" SECTION 1: TROUBLE DIAGNOSIS AND CHECKING PROCEDURE
Service Check List
Service Tools
Diagnosis Charts
Will Not Run
Will Not Heat
Clothes Not Drying
Blowing Fuses
Moisture Retention Unsatisfactory
Drying Temperature Too High
Motor Runs With Door Open
Germicidal Bulb Fails to Light
Drum Bulb Does Not Light
Drum Will Not Rotate
Will Not Shut Off
Timer Does Not Advance
Grow Coil Does Not Light
No Pilot Flame - Glow Coil Lights
Pilot Light Goes Out
Main Burner Will Not Ignite - Pilot Burning
Burners - Standing Pilot
Burners - Direct Ignition
SECTION 2: SERVICE PROCEDURES -
ELECTRICAL COMPONENTS
Power Supply
Three-Wire Hook-Up
Two-Wire Hook-Up
Grounding
Neutral Terminal Grounding
Separate Wire Grounding
Electrical Testing
Heating Element
Timers
Cycle of Operation
Timer Motors
Switch Box
Single, and Dual Cycle Timers
Three-Cycle Timers
Convertible Dryer Components
Push-to-Start Switch
Push-to-Start Relay
Speed Selector Switch
Electronic Control Timer
Electronic Control Service
Electronic Dry Control System
Timer Testing
Chain Drive
Switches
Door Switch
Centrifugal Motor Switch
Centrifugal Fan Switch
Solenoid Relay
Heat Relay Switch
Three-Cycle Relay Switch
Heat Element Relay
Modulating Relay Switch
Main Burner and Timer Motor Relay Switch
Air Heat Switch
Selector Switch
O.S.O. Switch
Thermostats
Fixed Thermostats
High Limit Thermostats
Adjustable Thermostats
Sensor Thermostats
Lights
Drum Light
Ozone Light
Motors
Motor Centrifugal Switch
Motor Testing Test Cord
Motor Repairs
Convertible Dryer Motor
Motor Test
SECTION 3: SERVICE PROCEDURES -
MECHANICAL COMPONENTS
Cabinets
Cabinet Top
Console
Rear Panel
Clothes Door
Bulkhead and Bearing Support
Drum Assembly
Drum Adjustment
Drum Seal
Air Circulation System
Venting and Lint Screen
Convertible Dryer Air Circulator
Drive Mechanism
Belts
Blower Belts
Blower Assemblies br> Preventive Maintenance Hints
Convertible Dryer, Mechanical System
Air Duct and Blower Wheel
SECTION 4: SERVICE PROCEDURES -
GAS COMPONENTS
Manual Ignition Burners
Thermocouples
Electromagnet
Thermocouple Tester
Unlatch Mechanism
Zip Tube
Electric Ignition Burners
Mercury Vapor Switch
Servicing the Gas Burner
Bench Testing
Modulating Burners
Two-Level Input Burners
Direct Ignition Burners
Glo-Sil Ignitor
Gas Control Valve
Glo-Sil Ignitor Service
Direct Ignition Bench Test
Diode and Resistor Function
Pilot and Main Burner Bodies
Gas Valve
Pilot Burners
Primary and Secondary Air Flame Characteristics
Flame Characteristics
Gases
Pressure Regulator
Checking Manifold Pressure
Importance of Adjustment
Gas Burner Orifice Chart
Zip Tube Chart
Main Burner Orifice Chart
SECTION 5: PARTS LIST
Blower Assembly
Modulating Burner Assembly
Dole Burner Assembly
White Rogers Manual Ignition Burner
Instant Ignition Burner
Basoid Burner
Burner Assembly 339097 with Glo-Bar Ignition
Burner Assembly 339096 with Glo-Bar Assembly
Glossary of Terms
INDEX "
This is a previously owned library book with several library stamps, stickers and markings including a pocket at the end.
The cover has some clear tape for protection along the binding.
There are several stains and dirt marks on the cover.
No torn or ripped pages, but the cover is loose from the pages.
|